无需付费看美女直播的软件,亚洲AV无码乱码国产精品,色婷婷一区二区三区四区成人网,国产精品天天看天天做夜夜爽

您好!歡迎訪問上海胤煌科技有限公司網站!
全國服務咨詢熱線:

13390845525

當前位置:首頁 > 技術文章 > 超聲法粒度分析在乳劑行業的應用

超聲法粒度分析在乳劑行業的應用

更新時間:2020-03-24      點擊次數:2135

Acoustic Particle Sizing of Milk

超聲法粒度分析在乳劑行業的應用

Oil/Water, as well as, Water/Oil emulsions can partially degrade or even fully break up upon undergoing dilution. Thus, particle size measurements without dilution are desirable for emulsion characterization.

油/水以及水/油的乳液會在稀釋之后部分降解甚至*分解。因此,在不稀釋的情況下直接測量乳液的粒徑是一種理想方法。

The APS-100 Acoustic Particle Sizer1 measures -without the need for sample dilution Particle Size Distribution, Longitudinal Viscosity, Percent Solids, pH, Conductivity, and Temperature. Using a patented measurement design2, the APS-100 performs acoustic attenuation spectroscopy measurements in the ultrasonic range of 1-100 MHz.

美國MAS公司生產的APS-100超聲法粒度儀《1》可以不用稀釋,直接測量粒度分布,縱向粘度,固含量,PH值,電導率及溫度。通過測量設計《2》,APS-100可以在1-100MHz的超聲波范圍內進行聲學衰減光譜測量。

The resulting attenuation spectrum of dB/cm vs. Frequency (MHz) is used by a patented first-principle algorithm3 to calculate particle size distribution data without making assumptions regarding the shape of the particle size distribution, e.g. unimodal, bimodal, lognormal, Gaussian, etc. The APS-100 is calibrated with water without the need for particle size calibration standards.

通過使用原理算法使用產生的dB/cm / 頻率(MHz)的衰減譜來計算粒徑分布數據,而無需對粒徑分布的形狀進行假設,例如單峰、雙峰、對數正態、高斯等。APS-100是用水進行校準的,不需要使用粒度校準標準。

APS measurements are made by low-power (inaudible) short acoustic pulses (about 10 microseconds long) that do not affect the sample’s dispersion state as depicted in figure 1. Another instrument, the Zeta-APS, measures Zeta potential in addition to all these parameters.

APS測量采用低功率(聽不清)短聲脈沖(約10微秒長),不影響圖1所示的樣品的分散狀態。另外Zeta-APS儀器,除了測量上述所有這些參數外,還測量Zeta電位。

 

Fig. 1. Waveforms of the ultrasonic pulses applied and measured during Acoustic Particle Sizing.

圖1 - 超聲波脈測量粒度的過程中,超聲波的脈沖波形。

 

Fig. 2. Acoustic Attenuation Spectra of 4% wt silica-water sample (3 runs: ♦, ■, ▲) alongside DI water (x).

圖2 - 4%wt二氧化硅水樣(3次:♦, ■, ▲)和去離子水的聲衰減譜。

 

Fig. 3. Particle Size Distribution overlaid data for three consecutive runs of a 4% wt silica-water sample.

圖3 – 三次4%wt二氧化硅水樣的粒度分布數據疊加圖

Figures 2 and 3 show attenuation spectra and particle size distribution data for three consecutive runs of a silica-water sample at 4% wt percent solids level (Nissan Chemical, Houston, TX). A water (solvent) spectrum is also shown. A solvent spectrum (excluding the particles) is required for particle size computation.

圖2和圖3顯示了連續三次4%wt二氧化硅水樣的粒度分布和聲衰減譜(Nissan Chemical, Houston, TX)。水樣的譜圖也有顯示。粒徑計算需要溶劑譜(不包括微粒)。圖3所示的PSD在0.1微米有相當窄的分布,接近MP1040二氧化硅的標稱平均粒徑。

Emulsion Analysis

乳液測試分析

For this study, five consumer-type dairy samples were characterized as follows:

在本研究中,五種消費型乳液樣本的特征如下:

- Half and Half Cream (HHC) 半脂乳

- Whole Milk (WM) 全脂乳

- 1% Low-fat Chocolate Milk (CM) 1% 低脂巧克力乳 

- 1% Low-fat Milk (LFM) 1% 低脂乳

– Nonfat Milk (NFM) 脫脂乳

The samples were analyzed without dilution. They were continuously mixed by the APS- 100’s onboard mechanical mixer. Sample temperature was kept at 26 ºC by the APS- 100’s sample heater.

這些樣品沒有進行稀釋。他們是由APS-100的內置機械混合器連續混合。通過APS-100的加熱系統,保證樣品在26℃。

Acoustic Data

超聲數據

 

Fig. 4. Acoustic Attenuation Spectra for five milk samples.

圖4 – 5種乳劑樣品的超聲衰減波譜。

Figure 4 shows acoustic attenuation spectra, dB/cm vs. Frequency (MHz), for the five milk samples. Attenuation levels decrease in the following order due to each sample’s fat content level as follows (see below about the 1% chocolate milk sample):

HHC > WM > CM > LFM > NFM

圖4顯示了5種乳的dB/cm / 頻率(MHz)的衰減譜。由于每個樣品的脂肪含量水平,衰減水平按以下順序降低(見下文關于1%巧克力牛奶樣品):

HHC半脂乳 > WM全脂乳 > CM1% 低脂巧克力乳 > LFM 低脂乳> NFM脫脂乳

Regarding Chocolate vs. Low-fat milk, the difference in attenuation is due to the added chocolate flavor components.

關于巧克力和低脂乳,衰減的差異是由于添加了巧克力風味成分。

These samples were analyzed at 26 ºC, kept constant by the APS-100’s onboard heater. Also, the samples were continuously mixed during these measurements by the APS-100’s mechanical mixer.

這些樣品在分析過程中通過APS的加熱系統保持溫度在26℃。此外,在這些測量過程中,由APS-100的機械混合器連續混合樣品。

 

Fig. 5. Particle size distribution data for a whole milk sample by Acoustic Particle Sizing (APS-100).

圖5 – APS-100測量的全脂乳的粒度分布數據。

Figure 5 below presents the particle size distribution for a whole milk sample analyzed without dilution. The fat-free milk sample was used to represent the intrinsic attenuation required by the acoustic particle sizing computations4.

圖5顯示了未經稀釋而分析的全脂乳的粒度分布。脫脂乳樣品用于表示聲學顆粒尺寸計算所需的固有衰減《4》。

Intrinsic attenuation corresponds to the solvent attenuation, i.e. attenuation excluding the discrete phase (particles/droplets) of the sample. The particle and solvent physical properties required by the particle size computations were obtained from published data5.

固有衰減對應于溶劑衰減,即不包括樣品的離散相(顆粒/液滴)的衰減。顆粒尺寸計算所需的顆粒和溶劑物理性質是從已發表的數據中獲得的《5》。

Some of the corresponding particle size data for the whole milk sample are as follows:

全脂乳樣品的相應粒度數據如下

Mean particle size, Volume weighted: 1.8 µm, 25th, 75th percentiles: 0.9, 2.5 µm

Mean particle size, Area weighted: 1.1 µm, 25th, 75th percentiles: 1.46, 1.5 µm

體積平均粒徑:1.8μm,D25 為0.9μm,D75為2.5μm

面積平均粒徑:1.1μm,D25 為1.46μm,D75為1.5μm

 

 

Figure 6 above corresponds to a sample of half and half creamer measured by an APS- 100 instrument without dilution. The particle size data is as follows:

Mean particle size, Volume weighted: 1.45 µm, 25th, 75th percentiles: 0.53, 2.6 µm

Mean particle size, Area weighted: 0.65 µm, 25th, 75th percentiles: 0.2, 0.68 µm

圖6對應的是用APS- 100儀器測量的沒有稀釋半脂乳樣品的測試數據:

體積平均粒徑:1.45μm,D25 為0.53μm,D75為2.6μm

面積平均粒徑:0.65μm,D25 為0.20μm,D75為0.68μm

REFERENCES

1. Matec Applied Sciences, Northborough, MA USA, www.matecappliedsciences。。com)

2. US Patent 6,604,408

3. US Patent 6,119,510

4. McClements, D. J., and Povey, J. W., Ultrasonic analysis of edible fats and oils, Ultrasonics, vol 30, 6, 1992.

5. Lopez, C., Briard-Bion, V., Camier, B., Gassi, J. Y., Milk Fat Thermal Properties and Solid Fat Content in Emmental Cheese: A Differential Scanning Calorimetry Study, J. Dairy Sci., 89:2894-2910, 2006/

上海胤煌科技有限公司
地址:上海市浦東新區航川路18號
郵箱:info@yh-tek.com
傳真:021-58220558
關注我們
歡迎您關注我們的微信公眾號了解更多信息:
歡迎您關注我們的微信公眾號
了解更多信息
国产精品情侣呻吟对白视频| 日产A一A区二区| 特黄特色大片免费播放器下载| 麻豆国产AV丝袜白领传媒| 老熟女高潮一区二区三区| 成年女人A毛片免费视频| 国产性色AV高清在线观看| 全黄性性激高免费视频| 最近日本MV字幕免费观看| 极品少妇XXXX精品少妇偷拍| 精品无码黑人又粗又大又长AV| 97久久精品人人槡人妻人| 久久精品国产亚洲AV网站| 丰满人妻一区二区三区免费视频| 免费A级毛片无码免费视频APP| 国产做A爱免费视频在线观看| 男人放进女人阳道视频观看| 特级毛片绝黄A片免费播冫| 美人双性受H多人运动NP| 永久免费AV无码网站在线观看| 亚洲中文字幕久久精品无码喷水| 国产AV无码一区二区三区| 性无码一区二区三区在线观看| 少妇撒尿W搡BBB搡WBBB搡| 麻豆高潮AV久久久久久久| 亚洲一区二区三区日本久久九| 妽妽的下边好紧春雨医生| 人妻放荡乱绿帽H文| 宝贝腿再张大点就能吃到扇贝了| 成熟丰满熟妇高潮XXXXX| 国产超碰人人爽人人做人人添| 亚洲一区二区三区| 日本一欧美一欧美一亚洲| 野外被三个男人躁一夜小说| 精品国模一区二区三区| 老熟妇仑乱视频一区二区| 亚洲精品国产SUV一区88| 久久丫精品国产亚洲AV妓女| 国产精品久久久久久人妻| 成人爽A毛片免费啪啪| 少妇激情出轨100篇|